Fourth Court of Appeals
San Antonio, Texas
MEMORANDUM OPINION
No. 04-14-00620-CV
Rosa Obregon PEREZ, Ricardo O. Perez, Rosa Elia Perez, Maria Perez Jalomus, Juan Jose
Perez, Julio Perez, Jr., and Fernando Perez,
Appellants
v.
The Goodyear Tire &
THE GOODYEAR TIRE & RUBBER COMPANY,
Appellee
From the 83rd Judicial District Court, Val Verde County, Texas
Trial Court No. 26130
Honorable Robert Cadena, Judge Presiding
Opinion by: Rebeca C. Martinez, Justice
Sitting: Sandee Bryan Marion, Chief Justice
Rebeca C. Martinez, Justice
Luz Elena D. Chapa, Justice
Delivered and Filed: August 19, 2015
AFFIRMED IN PART; REVERSED AND REMANDED IN PART
In this products liability case, Rosa Obregon Perez, Maria Perez Jalomus, Rosa Elia Perez,
Juan Jose Perez, Julio Perez, Jr., Fernando Perez, and Ricardo O. Perez (collectively referred to as
“Perez”) challenge the trial court’s take-nothing summary judgment rendered in favor of The
Goodyear Tire & Rubber Company. Perez asserts that the trial court erred in granting Goodyear’s
no-evidence motions for summary judgment as to her defective design and defective marketing
claims. As a subset of this issue, Perez contends that the trial court erred in excluding the affidavit
04-14-00620-CV
testimony of her retained tire expert, William J. Woerhle. We affirm in part, and reverse and
remand in part.
FACTUAL AND PROCEDURAL BACKGROUND
On February 14, 2006, Julio O. Perez, Sr. was transported for a dialysis appointment from
Del Rio to Uvalde in a Ford E-350 van that had been converted into an ambulance owned by
Medical Transport of South Texas, Inc. While traveling on U.S. Highway 90, the tread of a
Goodyear Wrangler HT LT245/75 R16 tire separated. The separation of the tire caused the driver
to lose control, and the ambulance rolled over. Mr. Perez died from injuries he sustained in the
accident.
Perez filed suit against Medical Transport of South Texas and the ambulance driver
asserting wrongful death and survival claims; Perez later amended the petition to assert claims
against Ford Motor Company and Goodyear. Perez claimed Goodyear was liable under strict
liability and negligence theories for defectively designing, manufacturing, and marketing of the
tire at issue. In 2010, Perez resolved her claims against all defendants except Goodyear.
In her “Eighth Amended Original Petition,” Perez alleged that the tire at issue was
defectively designed, manufactured, and marketed and that Goodyear was strictly liable under
Sections 402A and 402B of the Restatement of Torts 2nd and under applicable products liability
law of the State of Texas. Perez also alleged that Goodyear was negligent in failing to: (1) properly
design the tire in question; (2) properly manufacture the tire in question; (3) properly warn that
tires six years old or older should not be used regardless of tread life; (4) properly design the tire
in question to include nylon overlays on the tire; (5) warn that tires six years old or older should
not be used regardless of tread life; and (6) warn that the subject tire did not have nylon overlays
and was at a high risk for tread separation.
-2-
04-14-00620-CV
Goodyear timely filed its motion to exclude the expert testimony of Woehrle. Goodyear
also filed a no-evidence motion for summary judgment on each of the liability theories contained
in Perez’s live pleadings. The parties filed numerous supplements, responses, replies, and
objections relating to the pending motion to exclude and the motion for summary judgment.
Thereafter, Goodyear filed a second no-evidence motion for summary judgment. The parties again
filed responses, replies, and supplements.
On May 7, 2014, the trial court granted Goodyear’s motion to exclude Woehrle’s testimony
without stating the basis for its decision. On June 2, 2014, the trial court granted a partial no-
evidence motion for summary judgment on Perez’s “alleged manufacturing defects and negligent
manufacturing” claims, 1 as well as on Perez’s “claims based upon tire aging and failure to warn
about the age of the tire.” On July 11, 2014, the trial court signed a second summary judgment
order in favor of Goodyear as to the “alleged design defect and negligent design” claims.
Thereafter, on July 31, 2014, the trial court signed a “Final Judgment” in which it resolved
and disposed of all claims and all parties in the litigation. Perez timely filed her notice of appeal. 2
I. EXCLUSION OF EXPERT TESTIMONY
We first address whether the trial court erred in excluding the testimony of tire expert
Woerhle.
1
On appeal, Perez does not challenge the granting of summary judgment as to her manufacturing claims.
2
In its appellee’s brief, Goodyear asserts that Perez’s notice of appeal was untimely and that we lack jurisdiction to
entertain this appeal. Goodyear contends that once the trial court signed the second order granting the no-evidence
summary judgment as to design defect on July 11, 2014, all claims and parties were disposed of and thus the July 11,
2014 order became an appealable judgment from which the appellate timetable began to run. We disagree that the
second summary judgment order disposed of all outstanding claims. To the contrary, the sixth negligence claim
asserted in Perez’s “Eighth Amended Original Petition” was not addressed by either the June 2, 2014 or July 11, 2014
orders; in that claim, Perez alleged that Goodyear “[f]ailed to warn that the subject tire did not have nylon overlays
and was at a high risk for tread separation.” Because the nylon overlay marketing claim was still outstanding, the July
31, 2014 “Final Judgment” is in fact the final, appealable order from which the appellate timetable began to run and
from which Perez timely filed her notice of appeal.
-3-
04-14-00620-CV
A. Standard of Review and Applicable Law
We may not disturb the trial court’s exclusion of expert testimony absent an abuse of
discretion. Gammill v. Jack Williams Chevrolet, Inc., 972 S.W.2d 713, 718-19 (Tex. 1998). “The
test for abuse of discretion is whether the trial court acted without reference to any guiding rules
or principles.” E.I. du Pont de Nemours & Co., Inc. v. Robinson, 923 S.W.2d 549, 558 (Tex.
1995). We cannot find an abuse of discretion merely because we disagree with the trial court’s
decision. See id. This court has held that when “an expert’s testimony lacks a reliable scientific
basis, its admission by the trial court constitutes an abuse of discretion.” Martinez v. City of San
Antonio, 40 S.W.3d 587, 593 (Tex. App.—San Antonio 2001, pet. denied) (quoting Ford Motor
Co. v. Aguiniga, 9 S.W.3d 252, 262 (Tex. App.—San Antonio 1999, pet. denied)). When, as here,
the trial court does not specify the ground on which it excluded the expert’s testimony, we may
affirm the trial court’s ruling if any ground is meritorious. K-Mart Corp. v. Honeycutt, 24 S.W.3d
357, 360 (Tex. 2000).
An expert witness may testify regarding scientific, technical, or other specialized matters
if the expert is qualified, the expert’s opinion is relevant to the issues in the case, and the opinion
is based upon a reliable foundation. See TEX. R. EVID. 702; Robinson, 923 S.W.2d at 556 (adopting
analysis of Daubert v. Merrell Dow Pharms., Inc., 509 U.S. 579, 589-90 (1993)). “To be relevant,
the proposed testimony must be ‘sufficiently tied to the facts of the case that it will aid the jury in
resolving a factual dispute.’” Robinson, 923 S.W.2d at 556; see also TEX. R. EVID. 401, 402. To
be reliable, the opinion must be based on sound reasoning and methodology. State v. Cent.
Expressway Sign Assocs., 302 S.W.3d 866, 870 (Tex. 2009); Robinson, 923 S.W.2d at 557.
Opinion testimony that is conclusory or speculative is not relevant evidence because it does not
tend to make the existence of a material fact more probable or less probable. See TEX. R. EVID.
401; City of San Antonio v. Pollock, 284 S.W.3d 809, 816 (Tex. 2009). Expert testimony is
-4-
04-14-00620-CV
unreliable if it is no more than subjective belief or unsupported speculation. TXI Transp. Co. v.
Hughes, 306 S.W.3d 230, 239 (Tex. 2010); Robinson, 923 S.W.2d at 557.
An expert must be qualified “by knowledge, skill, experience, training, or education” to
“assist the trier of fact to understand the evidence or to determine a fact in issue.” TEX. R. EVID.
702; In re Commitment of Bohannan, 388 S.W.3d 296, 304 (Tex. 2012). There are no definite
guidelines to determine whether a witness’ education, experience, skill, or training qualifies the
witness as an expert. W. Atlas Int’l., Inc. v. Wilson, 930 S.W.2d 782, 787 (Tex. App.—Tyler 1996,
writ denied). The witness may express an opinion on a subject if the witness has specialized
knowledge that will assist the trier of fact in understanding the evidence or in determining a fact
in issue. Id. “The specialized knowledge which qualifies a witness to give an expert opinion may
be derived from specialized education, practical experience, a study of technical works, or a
varying combination of these things.” Penry v. State, 903 S.W.2d 715, 762 (Tex. Crim. App.
1995). Ultimately, in deciding whether an expert is qualified, the trial court must “ensur[e] that
those who purport to be experts truly have expertise concerning the actual subject about which
they are offering an opinion.” Gammill, 972 S.W.2d at 719 (quoting Broders v. Heise, 924 S.W.2d
148, 152 (Tex. 1996)).
In determining whether expert testimony is reliable, a reviewing court must employ “‘an
almost de novo-like review and, like the trial court, look beyond the expert’s bare testimony to
determine the reliability of the theory underlying it.’” Gross v. Burt, 149 S.W.3d 213, 237 (Tex.
App.—Fort Worth 2004, pet. denied) (quoting Austin v. Kerr-McGee Refining Corp., 25 S.W.3d
280, 285 (Tex. App.—Texarkana 2000, no pet.)). “An expert’s simple ipse dixit is insufficient to
establish a matter; rather, the expert must explain the basis of his statements to link his conclusions
to the facts.” Earle v. Ratliff, 998 S.W.2d 882, 890 (Tex. 1999) (citing Gammill, 972 S.W.2d at
726-27). In assessing the admissibility of expert testimony, we do not focus on the correctness of
-5-
04-14-00620-CV
the expert’s opinion, but on the reliability of the analysis the expert used in reaching his or her
conclusions. Gross, 149 S.W.3d at 237; see also Robinson, 923 S.W.2d at 558 (“The trial court’s
role is not to determine the truth or falsity of the expert’s opinion.”).
The Texas Supreme Court has articulated six non-exclusive factors appellate courts may
consider in determining whether scientific evidence is reliable:
(1) the extent to which the theory has been or can be tested;
(2) the extent to which the technique relies upon the subjective interpretation
of the expert;
(3) whether the theory has been subjected to peer review and/or publication;
(4) the technique’s potential rate of error;
(5) whether the underlying theory or technique has been generally accepted as
valid by the relevant scientific community; and
(6) the non-judicial uses that have been made of the theory or technique.
Robinson, 923 S.W.2d at 557. The approach to assessing reliability must be flexible depending
on the nature of the evidence. Transcon. Ins. Co. v. Crump, 330 S.W.3d 211, 216-17 (Tex. 2010).
One additional consideration is whether the expert has ruled out alternative causes of injury; failure
to do so may render the opinion unreliable. See Robinson, 923 S.W.2d at 559 (holding expert’s
testimony was not based upon a reliable foundation where he failed to conduct testing to exclude
other possible causes of damage); Martinez, 40 S.W.3d at 593. Another is whether the expert’s
research and opinions were conducted and formed solely for the purpose of litigation. See
Robinson, 923 S.W.2d at 559.
The Robinson factors, however, do not always apply to expert testimony because they are
not always appropriate. Gammill, 972 S.W.2d at 726-27; Goodyear Tire & Rubber Co. v. Rios,
143 S.W.3d 107, 113 (Tex. App.—San Antonio 2004, pet. denied). “Experience alone may
provide a sufficient basis for an expert’s testimony in some cases, but it cannot do so in every
case.” Gammill, 972 S.W.2d at 726. Regardless of whether the Robinson factors are applied, the
proponent of the expert testimony must still prove that the testimony is reliable. Id. In such a
-6-
04-14-00620-CV
case, the court must consider whether there is too great of an “analytical gap” between the data
and the expert’s opinion. Id.
B. Qualifications
In its motion to exclude Woehrle’s testimony, Goodyear argued that Woehrle is not
qualified to testify as to design defects because he is not a professional licensed engineer and he
has never designed or manufactured a steel belted radial tire.
Our review of Woehrle’s supplemental affidavit reveals that he obtained a Bachelor of
Science degree in physics in 1966. Upon graduation, he began working at Uniroyal Tire Company,
where he was employed for 25 years. Uniroyal merged with Goodrich and became
Uniroyal/Goodrich in 1986. Woehrle held various positions at Uniroyal, including: Development
Engineer; Resident Engineer; Project Manager of the Marketing Department; Automotive Account
Engineer; Manager of Industry Standards; Manager of Testing Services; and Director of Product
Evaluation. He served as Development Engineer in the Advanced Tire Products Department for
three years, during which time he received extensive training in the proper methodology to use in
analyzing and determining the cause of failed tires. Such methodology involves visual and tactile
examination of the failed tire. Woehrle also developed tests for radial ply tires. In 1969, he
assumed the role of resident engineer at a test facility that ran vehicles ten million miles annually
to test tires. There, Woehrle tested “bias ply tires” manufactured by Uniroyal as well as
experimental “steel belted radial ply tires with nylon overlay” that Uniroyal was developing at the
time.
In 1972, he was promoted to project manager of the marketing department where he
developed a program for the company’s tire and vehicle service centers to use to assess the ride
and handling quality of the vehicles equipped with these new steel belted radial ply tires. He
worked closely with Uniroyal dealers and taught them how to examine and determine the cause of
-7-
04-14-00620-CV
failed tires. In 1976, Woehrle was promoted to automotive account engineer. In that role, he
oversaw tests performed on Uniroyal tires for General Motors and also General Motors’
qualification tests, all of which were being conducted on experimental tires to assess tire durability
and ensure Uniroyal tires supplied to General Motors without nylon overlays had the same
durability as Uniroyal steel belted radial ply tires with nylon overlays. In 1978, he became
manager of industry standards and coordinated with other tire companies and governmental
agencies to set technical standards for tires. He led the company’s industry-sponsored tire research
and developed new procedures for testing tires. He was also involved in analyzing and reporting
on failed tires. In 1984, he assumed the role of manager of testing services where he performed a
wide variety of tests on both production tires and experimental tires. In 1987, after Uniroyal
merged with Goodrich, Woehrle became the director of product evaluation. He managed the
testing services for the entire research and development and manufacturing operations of the
company. He also led efforts to standardize procedures for tire testing with the Society of
Automotive Engineers and the International Standards Organization.
In 1992, Woehrle formed Automotive Engineering Management Services, Inc., a company
dedicated to serving the automobile industry by focusing on testing services. Its customers
included General Motors, Ford, Chrysler, Goodyear, Michelin, Dunlop, and major auto part
suppliers. Since 2005, Woehrle has worked as a consultant and expert witness for tires involved
in motor vehicle accidents. He has authored several published articles on various tire issues,
including tread separation.
Given Woehrle’s lengthy and direct experience in the tire industry with tire manufacture
and failure analysis, we hold that he is qualified to testify as an expert by reason of his knowledge,
skill, experience, training, and education. See TEX. R. EVID. 702; In re Commitment of Bohannan,
388 S.W.3d at 304-05; Gammill, 972 S.W.2d at 719.
-8-
04-14-00620-CV
C. Reliability
Goodyear also challenged the reliability of Woehrle’s design defect opinion, arguing that
it failed to pass muster under Robinson/Daubert. It also argued that Woehrle failed to fill the
analytical gap between his theories regarding the lack of a nylon overlay and the subject tire.
The subject tire is a Goodyear Wrangler HT LT245/75 R16 that was manufactured in 1997
without a nylon overlay. By 2000, Goodyear had added a nylon overlay to the design of these
tires. In his affidavit, Woehrle explained how tire belt separation can occur and how it can be
prevented, specifically, by the addition of a nylon overlay.
[M]y opinion that nylon overlays protect against belt separation failure is based, in
part, upon my review of the Goodyear documents and the depositions of the
Goodyear employees, particularly [Joseph] Zekoski, [Richard] Olsen[,] and Beale
Robinson. As I have explained hereinabove, I have direct experience with the
adverse effects on tire durability performance associated with the removal of a
nylon overlay. Likewise, I have direct experience with the corresponding
improvement associated with the addition of a nylon overlay. Specifically, I have
personally supervised countless tests and reviewed the test results of each test while
working at Uniroyal, where the goal of each test was to observe and investigate the
role of nylon overlay in the improvement of tire endurance.
Woehrle thus opined that the lack of a nylon overlay in the subject tire constituted a design defect.
The subject tire was eight years old at the time of the accident and had more than one half
of its tread left when the tread separation occurred. Woehrle performed a visual and tactile
examination of the subject tire and large piece of tread that had separated from the tire carcass and
determined that the tire did not have a nylon overlay. X-rays were also taken of the subject tire
that confirmed a “dog ear” in the bottom belt and an overlap in the bottom belt cables.
Based upon this forensic tire inspection and review of the accident scene photographs,
Woehrle concluded that the subject tire failed due to a detachment of the tread and top belt, and
that the top belt separated in more than one piece. Woehrle opined that the cause of the failure of
the subject tire was unsatisfactory adhesion in the belt skim rubber, the thin inner liner, a laxity in
-9-
04-14-00620-CV
Goodyear’s tolerances in its belt placement, and the absence of a nylon overlay. As the basis for
his opinion, Woehrle relied on several articles as well as confidential Goodyear documents and the
deposition testimony of Goodyear employees. He further opined that the addition of a nylon
overlay would have been a safer alternative design, and one that was both economically and
technologically feasible to install. Specifically, a “nylon overlay could have been easily added to
the subject tire as a measure to overcome belt imperfections and an inferior belt skim rubber.”
As part of his inspection, Woehrle ruled out other potential causes of failure, such as
customer abuse (i.e., over-deflection or under-inflation), road impact hazard, or improper repair.
There was no evidence that the ambulance was operating at an excessive speed. There was also
no evidence of a puncture or previous repair to the tire.
Goodyear contends that Woehrle’s design defect opinion is unreliable because he: has
never designed a nylon overlay for a steel belted radial tire; holds no patents of nylon overlays;
has not published any scientifically reliable peer reviewed literature that addresses the design, uses,
or benefits of nylon overlays; has never specified a nylon overlay for use in a steel belted tire; has
never done any comparison testing on a Wrangler HT LT245/75 R16 tire with and without a nylon
overlay; has agreed under oath that there is no publication that states that tires must have nylon
overlays to be adequate or non-defective; and has testified that just because a tire does not have a
nylon overlay does not mean that the tire is defective.
Woehrle does not, however, contend that all tires lacking a nylon overlay harbor a design
defect. Instead, he focuses on “Goodyear Load Range E tires manufactured in the mid to late
1990s that were manufactured without a nylon overlay that Goodyear discovered were
experiencing a dramatic increase in tread separations which led to Goodyear deciding to add a
nylon cap ply to their Load Range E tires which solved the tread separation problem.” Woehrle’s
design defect opinions were based, in large part, on Goodyear documents and Goodyear employee
- 10 -
04-14-00620-CV
depositions. In 1995, Goodyear recognized that there was a marked increase in damage claims in
its Load Range E tire from tread belt separations in the crown area of the tire. The problem was
described as a “weak boundary layer between the two belts” that “results in a separation between
the belts and often results in what has been called a tread throw since the top belt and tread separate
from the bottom belt and carcass.” Goodyear employed a team to investigate and analyze the tread
throw problem. The team recommended, in part, the addition of a nylon overlay on the LT235/85
R16 tire, but not on the LT245/75 R16 tire. The nylon overlay was implemented and was observed
to solve the tread separation problem. Goodyear eventually added the nylon overlay to all of its
Load Range E tires by 2000; however, the subject tire was manufactured in the 40th week of 1997
without a nylon overlay, approximately 20 months after the nylon overlay had been added to the
same tire line in size LT235/85 R16.
As evidence that Goodyear failed to exercise ordinary care in designing the tire at issue,
Woehrle also relied on the deposition testimony of Joseph Zekoski, who managed Goodyear’s
Light Truck Program from 1994-1996. Zekoski testified that the nylon overlay helps to distribute
stresses in the crown area away from the belt edges and provides structural integrity to the tires.
According to Zekoski, nylon overlays reduce strains at the belt edges thereby reducing the potential
for tread separation. Zekoski further testified that it was technologically and economically feasible
to add a nylon overlay to the Wrangler HT Load Range E tires when they were initially designed.
In 1998, Zekoski recommended that nylon overlays be added to all Goodyear Load Range E tires.
Thus, Zekoski’s testimony supports Woehrle’s opinion that the addition of a nylon overlay was
necessary to solve the tread separation defect in the tire at issue.
Woehrle also opined that the tire’s failure caused the ambulance driver to lose control. In
reaching this opinion, Woehrle reviewed the ambulance driver’s deposition as well as a report
from the National Highway Traffic Safety Administration (NHTSA) titled “Investigation of Driver
- 11 -
04-14-00620-CV
Reactions to Tread Separation Scenarios in the National Advanced Driving Simulator” which
showed that an inflated tire that has lost its tread and top belt loses 75 percent of its steering
capabilities and no longer functions as a normal tire. The NHTSA report thus supported Woehrle’s
opinion “that when the tread separation event occurred, the vehicle moved to the left into the
westbound lane of traffic and that when the driver inputted a right steer to bring the vehicle back
into the eastbound lane, as the tread separation event unfolded, that the vehicle spun out, and the
driver lost control and exited the roadway causing the driver’s loss of control and subsequent
rollover of the vehicle.” Woehrle also reviewed photographs and the police report from the
accident, as well as the deposition of Stan Andrews, Perez’s accident reconstruction expert, in
reaching his opinion that the tread separation on the subject tire caused the loss of control of the
ambulance. Finally, he relied on a report titled “The Effect of Tread Separation on Vehicle
Controllability” which found that the driver’s ability to maintain control of a vehicle is greatly
diminished and under certain conditions can be uncontrollable even by a skilled professional.
Analyzing Woehrle’s opinion testimony by the considerations provided in Robinson, we
conclude his opinions that the lack of a nylon overlay caused the tire at issue to fail and thus caused
the ambulance driver to lose control are based on sound reasoning and methodology. See
Robinson, 923 S.W.2d at 557-59. Woehrle’s opinions are supported by his lengthy experience in
the tire industry as well as Goodyear documents that show the addition of a nylon overlay would
have alleviated the tread separation issue in the subject tire. Woehrle also ruled out alternative
causes of injury, including other potential causes of tire failure and driver error. Further, because
Woehrle’s opinions on design defect and causation were supported by his experience, testing, and
observations, as well as by Goodyear documents and employee depositions demonstrating that the
tread separation issue could have been easily solved by the addition of a nylon overlay, we
conclude there are no analytical gaps in Woehrle’s opinions. See Gammill, 972 S.W.2d at 726-27.
- 12 -
04-14-00620-CV
Accordingly, we hold that Woehrle’s testimony was reliable. Having held that Woehrle is
qualified, his opinion is relevant 3 to the issues in the case, and his opinion is based upon a reliable
foundation, we conclude the trial court abused its discretion in excluding his testimony. 4 See TEX.
R. EVID. 702.
II. SUMMARY JUDGMENT
Having determined that the trial court erred in excluding Woehrle’s testimony, we now
examine whether the granting of summary judgment was proper.
A. Standard of Review and Applicable Law
After an adequate time for discovery, a party may move for no-evidence summary
judgment on the ground that no evidence exists of one or more essential elements of a claim on
which the adverse party bears the burden of proof at trial. TEX. R. CIV. P. 166a(i); Flameout Design
& Fabrication, Inc. v. Pennzoil Caspian Corp., 994 S.W.2d 830, 834 (Tex. App.—Houston [1st
Dist.] 1999, no pet.). The burden then shifts to the non-movant to produce evidence raising a
genuine issue of material fact on the elements specified in the motion. TEX. R. CIV. P. 166a(i);
Mack Trucks, Inc. v. Tamez, 206 S.W.3d 572, 582 (Tex. 2006). The trial court must grant the
motion unless the non-movant presents more than a scintilla of evidence raising a fact issue on the
challenged elements. Merrell Dow Pharms., Inc. v. Havner, 953 S.W.2d 706, 711 (Tex. 1997)
(“More than a scintilla of evidence exists when the evidence supporting the finding, as a whole,
‘rises to a level that would enable reasonable and fair-minded people to differ in their
3
Goodyear did not challenge the relevancy of Woehrle’s opinions in its motions for summary judgment. See TEX. R.
EVID. 702; Robinson, 923 S.W.2d at 556 (expert’s opinion must be relevant to the issues in the case).
4
In its motion to exclude Woehrle’s testimony, Goodyear also argued that certain opinions by Woehrle were untimely
because they were made after the September 1, 2011 designation deadline established by the trial court’s Discovery
and Docket Control Order. These opinions were, however, made known to Goodyear in Woehrle’s oral deposition,
and were therefore timely. See TEX. R. CIV. P. 193.5 (Amending or Supplementing Responses to Written Discovery).
- 13 -
04-14-00620-CV
conclusions.’”) (internal citations omitted). We indulge every reasonable inference and resolve
any doubts in the non-movant’s favor. Sw. Elec. Power Co. v. Grant, 73 S.W.3d 211, 215 (Tex.
2002). We review a no-evidence summary judgment ruling de novo. Provident Life & Accident
Ins. Co. v. Knott, 128 S.W.3d 211, 215 (Tex. 2003); Willmann v. City of San Antonio, 123 S.W.3d
469, 472 (Tex. App.—San Antonio 2003, pet. denied).
B. Design Defect and Negligent Failure to Properly Design Claims
In her “Eighth Amended Original Petition,” Perez alleged that Goodyear defectively
designed the tire in question and that Goodyear was negligent in failing to properly design the tire
in question and in failing to properly design the tire in question to include nylon overlays. To
recover for a products liability claim alleging a design defect, a plaintiff must prove that (1) the
product was defectively designed so as to render it unreasonably dangerous; (2) a safer alternative
design existed; and (3) the defect was a producing cause of the injury for which the plaintiff seeks
recovery. TEX. CIV. PRAC. & REM. CODE ANN. § 82.005(a) (West 2011); Timpte Indus., Inc. v.
Gish, 286 S.W.3d 306, 311 (Tex. 2009).
We previously determined that the trial court erred in excluding Woehrle’s testimony.
Perez thus relies on Woehrle’s affidavit to raise a genuine issue of material fact on all three
elements of her defective design claim. As outlined in his affidavit to show the tire was
“unreasonable dangerous,” Woehrle relied extensively on Goodyear documents and employee
depositions that showed Goodyear was aware, beginning in 1995, of an increase in tread belt
separations in the crown area of its Load Range E tires. These same documents also support
Woehrle’s opinion that the addition of a nylon overlay to the tire would have easily solved the
tread separation problem; i.e., that a safer alternative design was available. Finally, Woerhle’s
opinion that the failure of the tire caused the ambulance driver to lose control raises a fact issue as
to causation. As previously noted, Woehrle reviewed the accident site photographs and police
- 14 -
04-14-00620-CV
records, as well as the analysis of accident reconstruction expert Stan Andrews and the NHTSA
report titled “Investigation of Driver Reactions to Tread Separation Scenarios in the National
Advanced Driving Simulator” in reaching his opinion that the tread separation on the subject tire
caused the loss of control of the ambulance. Viewing this evidence, as we must, in the light most
favorable to the non-movant, we conclude that Perez produced more than a scintilla of evidence
that Goodyear designed a defective product. We thus conclude that summary judgment on Perez’s
defective design claim was improper.
Perez also provided more than a scintilla of evidence to support her negligent design claim.
As previously discussed, Woehrle’s design defect opinions were based, in large part, on Goodyear
documents and Goodyear employee depositions that demonstrate Goodyear had knowledge that
the tire at issue was experiencing tread separation problems that could be fixed by the addition of
a nylon overlay, yet chose not to implement the fix. Viewing this evidence, as we must, in the
light most favorable to the non-movant, we conclude that Perez produced more than a scintilla of
evidence that Goodyear failed to exercise ordinary care in designing the tire at issue. We thus
conclude that summary judgment on Perez’s negligent design claim was also improper.
C. Marketing Defect and Negligent Failure to Warn Claims
In her “Eighth Amended Original Petition,” Perez alleged that Goodyear failed to properly
warn that tires six years old or older should not be used regardless of tread life and failed to
properly warn that the subject tire did not have nylon overlays and was at a high risk for tread
separation. Specifically, Perez contends that Goodyear assumed a post-sale duty to warn of the
dangers created by the tire at issue, but failed to adequately convey the urgency of the matter. The
notice sent by Goodyear to owners of the 15-passenger vans and ambulance operators indicated
that if a tread separation occurs, it may necessitate pulling over to the side of the road to change
- 15 -
04-14-00620-CV
the tire. Perez contends that the warning should have been stronger, and should have warned that
tread separation may cause loss of control and a crash.
Whether a plaintiff seeks recovery because of negligence or strict liability in tort, the
burden is on the plaintiff to prove that the injury resulted from a defect in the marketing of the
product. See Ethicon Endo-Surgery, Inc. v. Gillies, 343 S.W.3d 205, 211 (Tex. App.—Dallas
2011, pet. denied); Ford Motor Co. v. Miles, 141 S.W.3d 309, 315 (Tex. App.—Dallas 2004, pet.
denied). A strict liability marketing defect cause of action consists of five elements: (1) a risk of
harm that is inherent in the product or that may arise from the intended or reasonably anticipated
use of the product must exist; (2) the product supplier must actually know or reasonably foresee
the risk of harm at the time the product is marketed; (3) the product must possess a marketing
defect; (4) the absence of the warning and/or instructions must render the product unreasonably
dangerous to the ultimate user or consumer of the product; and (5) the failure to warn and/or
instruct must constitute a causative nexus in the product user’s injury. Rios, 143 S.W.3d at 116.
To prevail on her negligent marketing claim, as opposed to a strict liability marketing defect claim,
Perez was required to establish four elements: 1) a duty by the defendant to act according to an
applicable standard of care; 2) a breach of the applicable standard of care; 3) an injury; and 4) a
causal connection between the breach of care and the injury. Ethicon, 343 S.W.3d at 211-12. In
its “Second No Evidence Summary Judgment Motion,” Goodyear alleged that Perez failed to
present any evidence to support any one of the elements of her marketing defect claim.
Expert testimony is required in the context of strict liability marketing defect claims. See
Nissan Motor Co., Ltd. v. Armstrong, 145 S.W.3d 131, 137 (Tex. 2004). In negligent marketing
cases, expert testimony will be required to establish the standard of care “when the alleged
negligence is of such a nature as not to be within the experience of the layman.” See FFE Transp.
Servs., Inc. v. Fulgham, 154 S.W.3d 84, 90-91 (Tex. 2004); Ethicon, 343 S.W.3d at 211.
- 16 -
04-14-00620-CV
Because the standard of care in marketing a particular tire is not within the experience of
laymen, we must conclude expert testimony was required to prove negligent marketing of the tire
at issue. See Fulgham, 154 S.W.3d at 90-91; Ethicon, 343 S.W.3d at 212; Rios, 143 S.W.3d at
118 (expert testimony required in defective marketing case to establish which warning and
instruction should have been printed on tire sidewall). Perez was thus required to offer expert
testimony that Goodyear failed to exercise ordinary care in the marketing of the HT LT 245/75R16
tire. See VIA Metro. Transit v. Garcia, 397 S.W.3d 702, 708 (Tex. App.—San Antonio 2012, pet.
denied); see also Rios, 143 S.W.3d at 118.
Woehrle does not hold himself out as a warnings expert, and at oral argument before this
court, Perez’s counsel conceded that if he needed a warnings expert to survive summary judgment
on the marketing claims, he did not have one. Given the lack of any expert testimony related to
the marketing of the tire at issue, we conclude that Perez failed to raise a genuine issue of material
fact on any of the elements of her negligent and defective marketing claims. Summary judgment
in favor of Goodyear on the negligent and defective marketing claims was thus proper.
CONCLUSION
Based on the foregoing, we reverse the portion of the trial court’s order granting summary
judgment in favor of Goodyear on Perez’s design defect claims, and we remand the case to the
trial court for further proceedings consistent with this opinion. In all other respects, we affirm the
judgment of the trial court.
Rebeca C. Martinez, Justice
- 17 -