[Until this opinion appears in the Ohio Official Reports advance sheets, it may be cited as State
ex rel. U.S. Tubular Prods., Inc. v. Indus. Comm., Slip Opinion No. 2021-Ohio-1174.]
NOTICE
This slip opinion is subject to formal revision before it is published in an
advance sheet of the Ohio Official Reports. Readers are requested to
promptly notify the Reporter of Decisions, Supreme Court of Ohio, 65
South Front Street, Columbus, Ohio 43215, of any typographical or other
formal errors in the opinion, in order that corrections may be made before
the opinion is published.
SLIP OPINION NO. 2021-OHIO-1174
THE STATE EX REL. U.S. TUBULAR PRODUCTS , INC., D.B.A. BENMIT HYDRO-
TESTERS DIVISION, APPELLANT, v. INDUSTRIAL COMMISSION OF OHIO ET AL.,
APPELLEES.
[Until this opinion appears in the Ohio Official Reports advance sheets, it
may be cited as State ex rel. U.S. Tubular Prods., Inc. v. Indus. Comm., Slip
Opinion No. 2021-Ohio-1174.]
Workers’ compensation—Violation of specific safety requirement—Industrial
commission did not abuse its discretion in granting additional award—
Record contained evidence supporting commission’s findings that specific
safety requirement applied, that employer violated it, and that violation was
proximate cause of injury—Court of appeals’ judgment denying writ of
mandamus affirmed.
(No. 2020-0883—Submitted January 26, 2021—Decided April 8, 2021.)
APPEAL from the Court of Appeals for Franklin County, No. 18AP-795,
2020-Ohio-3427.
__________________
SUPREME COURT OF OHIO
Per Curiam.
{¶ 1} Article II, Section 35 of the Ohio Constitution allows for an award of
additional compensation to a worker who sustains injuries as a result of his
employer’s violation of a specific safety requirement (“VSSR”). See also R.C.
4121.47. Appellee Industrial Commission granted appellee John R. Roush’s
request for such an award. Roush’s employer, appellant, U.S. Tubular Products,
Inc., d.b.a. Benmit Hydro-Testers Division, asked the Tenth District Court of
Appeals to issue a writ of mandamus ordering the commission to vacate its
decision. The Tenth District denied the writ, and U.S. Tubular appealed.
{¶ 2} Because the commission’s decision was supported by evidence in the
record, we affirm the Tenth District’s judgment.
I. FACTS AND PROCEDURAL HISTORY
A. Hydro-Testing
{¶ 3} U.S. Tubular’s operations include the “hydro-testing” of used pipes.
Hydro-testing involves forcing water pressure into a pipe to determine whether the
pipe leaks and needs to be repaired or does not leak and may be reused. U.S.
Tubular conducts these tests in a three-sided building known as the “test shelter.”
The process requires at least two employees; typically, one employee is stationed
at each end of the pipe being tested.
{¶ 4} Pipes roll into the test shelter on 42-inch-high racks that divide the
shelter into a north and south end. The employee at the north end attaches a cap
called a swage to that end of the pipe. Attached to the north-end swage is a hose
connected to a pump, which is in turn connected to a diesel engine. The north-end
employee then engages the pump, causing water to flow into the pipe.
{¶ 5} The south-end employee attaches a swage to that end of the pipe. The
south-end swage contains a slide valve. As the water flows into the pipe, it
displaces the air in the pipe, which exits through the slide valve. When water begins
flowing through the slide valve, indicating that all the air has been pushed out of
2
January Term, 2021
the pipe, the south-end employee slides the valve closed, by hand, thereby sealing
the pipe for pressurization.
{¶ 6} During the hydro-test, the two employees must retreat to designated
“safety zones” at each end of the test shelter. The controls for the hydro-test
machine are located in the north-end safety zone. The safety zones are necessary
because a swage sometimes blows off of a pressurized pipe. For that same reason,
U.S. Tubular has erected a “blast shield” to keep swages from going through the
wall of the test shelter.
{¶ 7} Once the south-end employee is in that end’s safety zone, the north-
end employee uses a lever and valve to increase the water pressure in the pipe to
the desired level. The pressure is maintained for a specific amount of time, during
which both employees, from their safety zones, observe the pipe for leaks. Then,
the north-end employee uses the controls to release the pressure in the pipe.
{¶ 8} The north-end employee signals the south-end employee when the
pressure has been released and it is safe to approach the pipe. This is typically done
by a “thumbs-up” sign or by the north-end employee simply leaving the safety zone
and moving toward the pipe. The employees must rely on visual signals because
the controls and pressure gauge for the hydro-tester are all housed in the north-end
safety zone and the testing process is too loud for them to communicate by voice.
The north-end controls provide the north-end employee with three means to
disengage the machine.
{¶ 9} The employee in the south end, whose safety zone is located behind a
yellow line, has no means to control the pressure or disengage the machine’s power
and has no gauges or other means that show when the pipe is under pressure. The
south-end employee cannot reach the machine’s controls from the south-end safety
zone and cannot efficiently take shelter in the north-end safety zone. The
employees are unable to communicate verbally because the work environment is
noisy, the employees wear ear protection, and the employees do not have radios.
3
SUPREME COURT OF OHIO
{¶ 10} Once the hydro-test is complete and the pressure is released, the
employees remove the swages from their respective ends of the tested pipe, the pipe
is marked to indicate the test result, and the team moves on to the next pipe,
repeating the process.
B. Roush’s Injury
{¶ 11} Roush sustained injuries while performing a hydro-test at U.S.
Tubular on December 10, 2014. He was working at the south end of the test shelter.
The employee working at the north end of the test shelter was Phil Drosnos.
{¶ 12} Roush and Drosnos attached their swages to a pipe that was 32 feet
long and approximately eight to ten inches in diameter. They then retreated to their
safety zones, and Drosnos engaged the pressure lever, pressurizing the pipe.
Drosnos apparently noticed that a swage was leaking; he left the safety zone and
approached the pipe to tighten the swage.
{¶ 13} The record is unclear whether Drosnos gave Roush a “thumbs up”
or whether Roush merely believed it was safe to approach the pipe because Drosnos
approached it. Regardless, Roush also left his safety zone and approached the pipe.
Drosnos then apparently realized that the pipe was still under pressure and returned
to his safety zone to depressurize it. Before Drosnos reached the pressure lever,
however, the swage on his end blew off, and the pent-up pressure projected the pipe
forward. It struck Roush in the abdomen with extreme force, knocking him to the
ground, where he hit his head on a floor grate. Roush sustained severe injuries. His
workers’ compensation claim was allowed for numerous abdominal, head, face,
and back conditions.
C. VSSR Award
{¶ 14} Roush filed an application for a VSSR award, asserting that U.S.
Tubular had violated three specific safety requirements set forth in the Ohio
Administrative Code. The Bureau of Workers’ Compensation’s Safety Violations
Investigation Unit conducted a site visit and interviewed U.S. Tubular personnel.
4
January Term, 2021
The investigator prepared a report that included photographs and a video of the
hydro-test operation.
{¶ 15} Both Roush and U.S. Tubular engaged experts to evaluate the
incident; each expert prepared a report. The bureau’s investigation report and the
experts’ reports were submitted to the commission, which also heard live testimony.
{¶ 16} The staff hearing officer (“SHO”) denied Roush’s VSSR claim with
respect to Ohio Adm.Code 4123:1-5-17(G)(1)(a)(i) (regarding protective headgear)
and 4123:1-5-17(I)(10) (regarding barriers and warning devices).
{¶ 17} But the SHO determined that Roush had established a violation of
Ohio Adm.Code 4123:1-5-05(D)(1), which provides, “Means shall be provided at
each machine, within easy reach of the operator, for disengaging it from its power
supply.” The SHO noted that Ohio Adm.Code 4123:1-5-01(B)(92) defines
“operator” as “any employee assigned or authorized to work at the specific
equipment.” The SHO determined that Roush was an “operator” of the hydro-test
machine, explaining:
The job of testing the pressurized pipe at the time of the industrial
injury is found to require two operators working together to test the
pipe. The Injured Worker’s job duties as the second test operator
were an integral part of the operation. * * * The second test
operator’s duty of closing the pipe is instrumental in pressurizing
the pipe.
The SHO also determined that the means of disengaging the equipment from its
power supply were not within Roush’s easy reach.
{¶ 18} Finally, the SHO found that the failure to comply with the safety
code was the proximate cause of Roush’s injury. The SHO noted that there was no
way for Roush to disengage the machine and relieve the pipe pressure and that
5
SUPREME COURT OF OHIO
Roush was injured when he was struck by a pressurized pipe. The SHO granted a
VSSR award of an additional 25 percent of the maximum weekly rate of
compensation.
{¶ 19} U.S. Tubular moved for rehearing. A different SHO denied the
motion. U.S. Tubular then moved for reconsideration. The commission vacated
the rehearing-denial order and set the matter for a hearing before the
commissioners.
{¶ 20} At that hearing, the parties addressed two issues: (1) whether the
commission had the authority under R.C. 4123.52 and State ex rel. Nicholls v.
Indus. Comm., 81 Ohio St.3d 454, 459, 692 N.E.2d 188 (1998), to exercise
continuing jurisdiction over the claim on the basis of a clear mistake of fact or law
and (2) if the commission exercised jurisdiction, whether the VSSR award should
be denied. The commission determined that it lacked the authority to exercise
continuing jurisdiction, reinstated the rehearing-denial order, and reiterated that the
original SHO order granting the VSSR award remained in effect.
D. Mandamus Action
{¶ 21} U.S. Tubular filed a mandamus complaint in the Tenth District,
seeking a writ compelling the commission to vacate the VSSR award. A magistrate
recommended granting the writ. 2020-Ohio-3427, ¶ 2. The commission objected.
Id. at ¶ 3. The Tenth District sustained the commission’s objections and denied the
writ. Id. at ¶ 28. U.S. Tubular appealed the Tenth District’s judgment.
II. ANALYSIS
A. Legal Standards
{¶ 22} “An award for a VSSR is ‘a new, separate, and distinct award’ over
and above standard workers’ compensation benefits.” State ex rel. Precision Steel
Servs., Inc. v. Indus. Comm., 145 Ohio St.3d 76, 2015-Ohio-4798, 47 N.E.3d 109,
¶ 15, quoting State ex rel. Newman v. Indus. Comm., 77 Ohio St.3d 271, 272, 673
N.E.2d 1301 (1997). “To be entitled to an additional award for a VSSR, a claimant
6
January Term, 2021
must show that (1) a specific safety requirement applied, (2) the employer violated
that requirement, and (3) the employer’s violation caused the injury.” Id.
{¶ 23} “To prevail on its claim for mandamus relief, [U.S. Tubular] must
demonstrate that the commission’s decision to issue a VSSR award was an abuse
of discretion. So long as some evidence supports the commission’s order, there
was no abuse of discretion, and the court must uphold the decision.” State ex rel.
Armstrong Steel Erectors, Inc. v. Indus. Comm., 144 Ohio St.3d 243, 2015-Ohio-
4525, 41 N.E.3d 1233, ¶ 13.
{¶ 24} “The interpretation of a specific safety requirement is within the final
jurisdiction of the commission and may be corrected in mandamus only upon a
showing that the commission abused its discretion.” Precision Steel at ¶ 21.
“[B]ecause a VSSR award is a penalty imposed on an employer, specific safety
requirements must be strictly construed and all reasonable doubts concerning the
interpretation of a particular safety regulation must be resolved in favor of the
employer.” Id.
B. Proposition of Law Nos. 1 and 2
The commission’s determination that Roush was an “operator” of the hydro-
test machine was supported by evidence in the record
{¶ 25} Ohio Adm.Code 4123:1-5-05(D)(1) provides, “Means shall be
provided at each machine, within easy reach of the operator, for disengaging it from
its power supply.” Ohio Adm.Code 4123:1-5-01(B)(92) provides that an
“operator” is “any employee assigned or authorized to work at the specific
equipment.”
{¶ 26} In proposition of law No. 1, U.S. Tubular argues that the commission
abused its discretion by finding that Roush was an operator of the hydro-test
machine. Specifically, U.S. Tubular asserts that Roush was not “assigned or
authorized to work at” the hydro-test machine, as required by Ohio Adm.Code
4123:1-5-01(B)(92). U.S. Tubular asserts that Roush worked 44 feet away from
7
SUPREME COURT OF OHIO
the machine, i.e., that the machine encompassed only the diesel engine and pump
on the north end of the test shelter and had no components in the south end of the
test shelter, at Roush’s end of the pipe. Therefore, U.S. Tubular asserts, Roush did
not operate the hydro-test machine.
{¶ 27} Relatedly, in proposition of law No. 2, U.S. Tubular argues that the
requirements of Ohio Adm.Code 4123:1-5-05(D)(1) apply only to a machine—not
to a facility or a process—and that it would be impossible to provide a means of
disengaging the hydro-test machine’s power that is both (1) within easy reach of
Roush and (2) “at [the] machine,” as Ohio Adm.Code 4123:1-5-05(D)(1) requires,
because Roush worked 44 feet away from the machine.
{¶ 28} It is undisputed that Ohio Adm.Code 4123:1-5-05(D)(1) applies to
the hydro-test machine and that U.S. Tubular did not provide a means of
disengaging the machine’s power within easy reach of Roush. Proposition of law
Nos. 1 and 2 therefore both hinge on whether Roush’s work area at the south end
of the test shelter placed him at the hydro-test machine. This question lies within
the final jurisdiction of the commission. Precision Steel, 145 Ohio St.3d 76, 2015-
Ohio-4798, 47 N.E.3d 109, at ¶ 21; State ex rel. Lange v. Indus. Comm., 111 Ohio
St.3d 563, 2006-Ohio-6211, 857 N.E.2d 593, ¶ 14. We may not find an abuse of
discretion so long as the commission’s determination is supported by some
evidence in the record, regardless of whether the record also contains contrary
evidence—even if greater in quantity or quality. State ex rel. Vonderheide v. Multi-
Color Corp., 156 Ohio St.3d 403, 2019-Ohio-1270, 128 N.E.3d 188, ¶ 14.
{¶ 29} Evidence in the record supported the commission’s determination
that Roush was an operator of the hydro-test machine, i.e., that he was “assigned or
authorized to work at the specific equipment,” (emphasis added) Ohio Adm.Code
4123:1-5-01(B)(92). More specifically, there was evidence from which the
commission could conclude that the components of the hydro-test machine
included the swage and slide valve that Roush was assigned to use. The Safety
8
January Term, 2021
Violations Investigation Unit’s report states, “The employer explained the tester
consisted of one engine, two pumps, two swages, and one hose.” (Emphasis added.)
The employer therefore acknowledged to the investigator that the swage at Roush’s
end of the pipe was a component of the hydro-test machine.
{¶ 30} Further, while U.S. Tubular now appears to argue that the “machine”
(a term that is not defined in the applicable code sections) is limited to the diesel
engine and pump located at the north end of the test shelter, it is undisputed that the
purpose of the hydro-test machine is not merely to pump water through a pipe but
to pressurize the pipe. And U.S. Tubular concedes that the hydro-tester cannot
pressurize the pipe without Roush first installing the south-end swage and then
closing that swage’s slide valve to seal the system for pressurization.
{¶ 31} The record also contained the report and testimony of Roush’s expert
witness, J. Douglas Jeter, a registered professional engineer. Jeter opined that both
Roush and Drosnos were operators of the hydro-test machine because “[t]he
operation cannot be accomplished by one person” and because Roush’s duties—
including closing the valve on his swage—were “an integral part of the
pressurization test.”
{¶ 32} In Jeter’s opinion, when the elements were all connected, they
constituted one machine: “When it is all connected, you have the south end swage
connected to the pipe connected to the north end swage connected by a hose to the
ball valve connected to the pump connected to the motor.” Roush was therefore
“operating his end of the unit which allows the system to become pressurized.”
And both employees are necessary for the machine to do its job: “If the north end
operator does not activate the valve, the ball valve, there won’t be any pressure. If
the south end operator does not close the [slide] valve, there won’t be any pressure.”
In his report, Jeter pointed out the problem, from a safety perspective, with the fact
that both Roush and Drosnos interacted with the machine and were in equal danger
in the event a pressurized pipe blew, yet only Drosnos had access to the controls:
9
SUPREME COURT OF OHIO
“Despite Mr. Roush’s safety being equally affected by the pressurization of the
system, he had no means of ensuring that it was in a zero energy state when he
approached it.”
{¶ 33} U.S. Tubular argues that three cases support the conclusion that the
commission abused its discretion by concluding that Roush was an operator of the
hydro-test machine. It argues that in State ex rel. Scott Fetzer Co., Halex Div. v.
Indus. Comm., 81 Ohio St.3d 462, 692 N.E.2d 195 (1998), the employee was found
to be an “operator” because he was “actively involved in the machine’s operation,”
id. at 466. However, our opinion in Scott Fetzer did not alter the definition of
“operator” set forth in Ohio Adm.Code 4123:1-5-01(B)(92), under which the
commission reasonably found Roush to be an operator of the hydro-test machine.
The remaining two cases applied a different definition of “operator” that predated
the current definition set forth in Ohio Adm.Code 4123:1-5-01(B)(92). See State
ex rel. Owens-Corning Fiberglas Corp. v. Indus. Comm., 62 Ohio St.2d 145, 146,
404 N.E.2d 140 (1980); State ex rel. Platt v. Diamond Internatl. Corp., 10th Dist.
Franklin No. 85 AP-979, 1987 WL 5893, *1 (Jan. 29, 1987). Those cases are
therefore inapplicable.
{¶ 34} Finally, U.S. Tubular invokes State ex rel. Frank Brown & Sons, Inc.
v. Indus. Comm., 37 Ohio St.3d 162, 524 N.E.2d 482 (1988), for the proposition
that a safety requirement must be specific enough to plainly apprise the employer
of its duty to the employee, id. at 163. Ohio Adm.Code 4123:1-5-05(D)(1), in
conjunction with Ohio Adm.Code 4123:1-5-01(B)(92), requires employers to
provide a means of disengaging a machine’s power supply within easy reach of
employees assigned or authorized to work at the machine. Based on U.S. Tubular’s
initial explanation of the hydro-test machine to the investigator, which stated that
the machine included both the north- and south-end swages, the record contains
evidence that U.S. Tubular was plainly apprised that both employees worked at the
10
January Term, 2021
hydro-test machine and should therefore have been provided with an easily
reachable means of disengaging the power.
{¶ 35} We reject proposition of law Nos. 1 and 2.
C. Proposition of Law No. 3
The commission’s determination that U.S. Tubular’s VSSR caused Roush’s
injury was supported by evidence in the record
{¶ 36} In proposition of law No. 3, U.S. Tubular argues that the commission
abused its discretion by finding that the VSSR was the proximate cause of Roush’s
injuries. U.S. Tubular asserts that Roush’s injuries were caused by his exiting the
safety zone while the pipe was pressurized, due to his own and/or Drosnos’s
negligence. However, the defense of unilateral negligence by an employee is
available to an employer in a VSSR case only if the employer has complied with
the specific safety requirement and the employee has unilaterally violated it. State
ex rel. Byington Builders, Ltd. v. Indus. Comm., 156 Ohio St.3d 35, 2018-Ohio-
5086, 123 N.E.3d 908, ¶ 39-40. As explained above, that is not the case here:
evidence supported the commission’s determination that U.S. Tubular violated
Ohio Adm.Code 4123:1-5-05(D)(1).
{¶ 37} U.S. Tubular also asserts that the existence, within easy reach of
Roush, of a means of disengaging the machine from its power source would not
have prevented Roush’s injury because Roush would still have approached the
pressurized pipe based on Drosnos’s mistakenly signaling that it was safe to do so.
This argument misses the point: if Roush had had an independent means of
disengaging the machine’s power, he would not have had to rely on a signal from
Drosnos in the first place.
{¶ 38} We rejected a similar argument in State ex rel. Glunt Industries, Inc.
v. Indus. Comm., 132 Ohio St.3d 78, 2012-Ohio-2125, 969 N.E.2d 252. In that
case, the employer “argue[d] that the absence of safety equipment did not
proximately cause [the] injury, because even if it had been available, [the injured
11
SUPREME COURT OF OHIO
worker] would not have used it.” Id. at ¶ 16. The employer based that argument
on the injured worker’s statement that “he did not need any safety equipment for
the task he was performing when he was injured.” Id. We concluded that the
employer’s assertion was “only conjecture” given the danger of the work
environment, which placed the injured worker in proximity to a high-voltage
circuit. Id. We also observed that the argument related less to proximate cause
than to a unilateral-negligence defense, which we noted was available only if the
employer complied with the specific safety requirement. Id. We reject U.S.
Tubular’s argument for the same reasons.
{¶ 39} We reject proposition of law No. 3.
III. CONCLUSION
{¶ 40} For the foregoing reasons, we affirm the Tenth District’s judgment.
Judgment affirmed.
O’CONNOR, C.J., and FISCHER, DONNELLY, and STEWART, JJ., concur.
KENNEDY, J., dissents, with an opinion joined by DEWINE, J.
BRUNNER, J., not participating.
_________________
KENNEDY, J., dissenting.
{¶ 41} I dissent from the majority’s affirmance of the judgment of the Tenth
District Court of Appeals, which held that appellee Industrial Commission did not
abuse its discretion when it found that appellant, U.S. Tubular Products, Inc.,
violated a specific safety requirement and that the violation proximately caused
appellee John R. Roush’s injuries. In my view, the commission abused its
discretion in concluding that U.S. Tubular violated a specific safety requirement
when it did not provide, within easy reach of Roush, a means to disengage a diesel
engine and pumps used in hydro-testing operations. The commission’s
determination that Roush was the operator of a machine merely because he was
integral to the testing process in which that machine was operated by another
12
January Term, 2021
employee runs contrary to the plain meaning of Ohio Adm.Code 4123:1-5-05(D)(1)
and Roush’s own testimony that he was not the operator of the machine. Therefore,
I dissent and would reverse the judgment of the Tenth District Court of Appeals
and grant a writ of mandamus ordering the commission to vacate its award for a
violation of a specific safety requirement (“VSSR”).
{¶ 42} To be entitled to an additional award over and above workers’
compensation benefits for a VSSR, Roush had to show that (1) a specific safety
requirement applied, (2) U.S. Tubular violated that requirement, and (3) the
violation caused his injury. State ex rel. Precision Steel Servs., Inc. v. Indus.
Comm., 145 Ohio St.3d 76, 2015-Ohio-4798, 47 N.E.3d 109, ¶ 15.
{¶ 43} The specific safety requirement at issue here, Ohio Adm.Code
4123:1-5-05(D)(1), provides that “[m]eans shall be provided at each machine,
within easy reach of the operator, for disengaging it from its power supply.” Ohio
Adm.Code 4123:1-5-01(B)(92), in turn, defines “operator” as “any employee
assigned or authorized to work at the specific equipment.” The word “machine” is
not defined in the applicable division of the Ohio Administrative Code. Therefore,
this court must accord that word its plain and ordinary meaning. See State ex rel.
Byington Builders, Ltd. v. Indus. Comm., 156 Ohio St.3d 35, 2018-Ohio-5086, 123
N.E.3d 908, ¶ 23-24 (applying the dictionary definition of a term not defined in the
Ohio Administrative Code).
{¶ 44} The most relevant definition of the word “machine” in the dictionary
is “an assemblage of parts that are usu[ally] solid bodies but include in some cases
fluid bodies or electricity in conductors and that transmit forces, motion, and energy
one to another in a predetermined manner and to some desired end.” Webster’s
Third New International Dictionary 1353 (2002); see also Merriam-Webster
Online, https://www.merriam-webster.com/dictionary/machine (accessed Mar. 25,
2021) [https://perma.cc/YGU5-PDZB] (defining “machine” as “a mechanically,
electrically, or electronically operated device for performing a task” and “an
13
SUPREME COURT OF OHIO
assemblage * * * of parts that transmit forces, motion, and energy one to another in
a predetermined manner”).
{¶ 45} U.S. Tubular’s hydro-testing operation uses pumps powered by a
diesel engine to pressurize a pipe that is capped at each end with a swage. The
north end of the pipe is capped with a threaded swage that has a hose attached to it.
The south end of the pipe is capped with a threaded swage to seal the pipe.
{¶ 46} Once the south-end employee caps the pipe with the threaded swage,
the employee moves to a safety zone, which is roughly 20 feet away from the south-
end employee’s workstation. The north-end employee then operates the machine
by opening a valve to the pump, thereby allowing water to fill the pipe, building
pressure to test the pipe.
{¶ 47} On the day of the accident, Roush was the south-end employee. His
functions were to screw the threaded swage onto the south end of the pipe and close
the valve on his swage once the pipe was full of water. Then, during pressurization,
Roush was required to move to his safety zone. Once the test was complete and
the pressure was released by the north-end employee, Roush was to return to the
south end of the pipe and remove his swage.
{¶ 48} The diesel-engine-powered pumps are plainly a machine within the
common usage of the word. The engine and pumps are mechanically operated to
perform a task—pressurizing the pipe—and they are assemblages of parts that
transmit force and energy. The swages and the pipe being tested are not
mechanically operated and they do not transmit force or energy—they do not move
at all during testing, and the swages are attached and removed by hand before and
after the machine is operated. Roush did not work “at the machine,” and therefore
U.S. Tubular was not required by Ohio Adm.Code 4123:1-5-05(D)(1) to provide a
kill switch within Roush’s reach.
{¶ 49} The majority relies on U.S. Tubular’s admission to an investigator
that “ ‘the tester consisted of one engine, two pumps, two swages, and one hose’ ”
14
January Term, 2021
as “acknowledg[ing] * * * that the swage at Roush’s end of the pipe was a
component of the hydro-test machine.” (Emphasis added in majority opinion.)
Majority opinion at ¶ 29. However, the words “tester” and “machine” are not
synonymous—a mercury thermometer is a fever tester, but it is not a machine
within the common usage of the word. U.S. Tubular admitted that the swages were
part of the testing process, but it did not concede that they were part of a “machine.”
{¶ 50} But even if the hydro-testing process as a whole could be considered
to be a machine, then Ohio Adm.Code 4123:1-5-05(D)(1) is ambiguous and could
refer both to the overarching testing process as well as the specific mechanical
equipment powering it.
{¶ 51} When a specific safety requirement is ambiguous, a court is required
to strictly construe it and to resolve all reasonable doubts concerning the meaning
and applicability of that particular requirement in favor of the employer. State ex
rel. 31, Inc. v. Indus. Comm., 152 Ohio St.3d 350, 2017-Ohio-9112, 96 N.E.3d 246,
¶ 21. A VSSR award is a penalty imposed on an employer, id., and we have
explained that specific safety requirements must establish “ ‘specific and definite
requirements or standards of conduct * * * [that] are of a character plainly to
apprise an employer of his legal obligation toward his employees,’ ” (ellipsis and
brackets added in Precision Steel) Precision Steel, 145 Ohio St.3d 76, 2015-Ohio-
4798, 47 N.E.3d 109, at ¶ 17, quoting State ex rel. Trydle v. Indus. Comm., 32 Ohio
St.2d 257, 291 N.E.2d 748 (1972), paragraph one of the syllabus.
{¶ 52} An employer cannot be penalized for failing to comply with a safety
requirement unless “mandatory specific duties are apparent to [the] employer
interpreting [the] provision.” State ex rel. Oliver v. Southeastern Erectors, Inc., 76
Ohio St.3d 26, 28, 665 N.E.2d 1108 (1996).
{¶ 53} As set forth above, the applicable provisions of the Ohio
Administrative Code do not define the word “machine.” Therefore, Ohio
Adm.Code 4123:1-5-05(D)(1) does not resolve the ambiguity and could not have
15
SUPREME COURT OF OHIO
plainly apprised U.S. Tubular that it was required to provide a kill switch at the
diesel engine and pumps as well as any other place near the hydro-testing process
where an employee was authorized to be, such as Roush’s work area, which was
roughly 40 feet from the engine and pumps at the north end of the pipe. Looking
at the common usage of the word “machine” and construing it strictly in favor of
the employer, as we must, Ohio Adm.Code 4123:1-5-05(D)(1) required U.S.
Tubular to have a kill switch only at the engine and pumps, and U.S. Tubular
complied with that duty. U.S. Tubular was not required to provide a kill switch
within Roush’s easy reach at the south end of the pipe.
{¶ 54} Roush’s own testimony at the hearing before the staff hearing officer
confirms this analysis. He testified:
Q. * * * In Paragraphs 13 and 14 of your affidavit, it says
“The controls to the tester were on the operator’s side.” What are
you referring to as the tester in that sentence?
A. The machine.
Q. The machine?
A. (Nodding head up and down.)
Q. Okay. And that’s the diesel engine and the pump,
correct?
A. Yes.
Q. Okay. And that was located on [the north-end
employee’s] side of the building?
A. Yes.
Q. Was not located on your side of the building?
A. No.
{¶ 55} Roush also explained his role in pressure testing the pipes:
16
January Term, 2021
Q. Then you put the swage on and that’s just threaded with
the ears, correct?
A. Yes.
Q. Tighten that by hand?
A. Yes.
Q. There’s no machinery that tightens that?
A. No.
Q. You’re just supposed to tighten it by hand. Then the
other operation you do is you close that slide valve. The slide valve
is located on the swage, correct?
A. Yes.
Q. Is the swage or the slide valve motorized at all?
A. No.
Q. That’s just a piece of metal, right?
A. Yes.
Q. Okay. All right. And other than that, were you operating
any equipment?
A. No.
Q. Okay. And [the north-end employee], at the other end of
the building, was the operator of the equipment?
A. Yes.
{¶ 56} Roush himself understood that the word “machine” referred only to
the diesel-powered pumps, not the swage that he hand-tightened onto the opposite
end of the pipe. Yet, notwithstanding Roush’s admission that he was not an
operator of the machine, his expert gave two reasons why he believed that Roush
was an operator—both of which the majority opinion relies upon in its analysis:
17
SUPREME COURT OF OHIO
first, Roush was integral to the pressure-testing operation, and second, Roush faced
the same hazard as the worker on the other end of the pipe and therefore deserved
to have the same protection (access to a kill switch). But being integral to a process
and a specific risk to the employee are not relevant to proving that Roush was an
operator of the machine. Rather, Ohio Adm.Code 4123:1-5-05(D)(1) requires a
kill switch within easy reach only when the employee is assigned or authorized to
work at the machine. Therefore, the expert’s opinion is not some evidence
supporting the commission’s finding.
{¶ 57} But even if Ohio Adm.Code 4123:1-5-05(D)(1) required a kill
switch at Roush’s end of the pipe, there is no evidence that a violation of that rule
caused Roush’s injury for three reasons. First, Roush mistakenly believed that the
pressure had been released from the pipe before he left his safety zone based on a
thumbs-up signal from the north-end employee. His own expert testified that Roush
would not have been able to know whether the pipe was pressurized since there was
no pressure gauge at Roush’s end of the pipe. There is no evidence that Roush
would have acted any differently had a kill switch been provided at his end of the
pipe, and it is his burden to prove that the lack of a kill switch caused his injury.
Second, a pressure gauge at his end of the pipe may or may not have prevented the
accident; but having a gauge is not a specific safety requirement established by the
commission and therefore cannot factor into an analysis of proximate cause. And
third, there is no evidentiary basis to believe that Roush would have had time to
engage a kill switch before the swage on the other end of the pipe failed. Roush’s
expert testified that Roush should have had a kill switch within the safety zone, but
Roush was not in the safety zone at the time of the accident. Kill switches are only
required to be “at the machine.” When Roush was in his safety zone he was not at
the machine—his safety zone was roughly 20 feet away from the hydro-testing
process.
18
January Term, 2021
{¶ 58} For these reasons, I would reverse the judgment of the Tenth District
Court of Appeals, grant a writ of mandamus, and vacate the VSSR award.
DEWINE, J., concurs in the foregoing opinion.
_________________
Krugliak, Wilkins, Griffiths & Dougherty Co., L.P.A., Edward D. Murray,
and Zachary M. Soehnlen, for appellant.
Dave Yost, Attorney General, and Natalie J. Tackett, Assistant Attorney
General, for appellee Industrial Commission of Ohio.
Mario Gaitanos, for appellee John R. Roush.
_________________
19